Edmunds Answers questions

Has anyone got a source for towing mirrors for a Chevy Express that replace the OEM mirrors?

garlic03 — Thu, 19 Jun 2008 23:36:10 GMT

Has anyone got a source for towing mirrors for a Chevy Express that replace the oem mirrors?

Chevy Express van 4.3. Runs bad off idle. No codes.

kstutz — Wed, 17 Jun 2009 14:04:48 GMT

Hi there and thanks for all you do to help here, hope you can help me.

I've got a 1999 2500 Express 4.3 It starts and idles perfect. Hot or cold it will accelerate till about 15 mph and then it seems to bog way down and barely accelerate at all. If I give it 1/2 throttle it will accelerate but slowly, it's loud like intake sound, and seems to really labor, and after a few ups and downs in speed it gets real hot (240-250deg). If I let up it smooths out and cools down. But a little more pedal and it surges slightly and has no power. It can hardly keep up speed over 45mp with out 1/2 throttle.

I have a small OBD II scanner and it shoes no codes. No "check engine light" and I don't hear knocking even with the tunnel off while driving.

Only other thing that started at the same time was the air conditioning compressor started cycling in and off at about 6 seconds on and 6 sec. off.

But I can't even use the AC cause it takes bogs the engine when it kicks on, it's that weak.

I've replaced the fuel filter, air filter, cap and rotor, plug wires, and checked the plugs, they looked good with correct gap.

I thought it feels like the timing is retarding, passably due to knock sensor signal. so I put in premium gas, no help.

I'm wondering if I can temporarily disconnect the K.S. to eliminate the portability of spark retard. That would eliminate a bad EGR or Knock Sensor.

It seems to get worse every time I drive it.

Any ideas?
Thanks again, Kevin in south Florida

02 Express 8.1L When starting starter stays engaged until shifting into reverse or drive. Any help on this matter.

scottrn — Mon, 18 Feb 2008 22:14:50 GMT

I have a 2002 Chevy Express 3500 8.1L When I start the van the starter stays engaged hitting the flywheel. This stops when I shift into reverse or drive. When driving down road I was hitting some bumps and the starter seemed to engage and then stop. The sound made was of trying to start your car while it is already started. A mechanic told me it's the transmission range select switch. Has anyone had this problem and does this sound like this would cause this problem. Thanks Scott

What city/highway mpg can I expect from a 2004 Chevrolet Express van with eight cylinder engine?

harbren2 — Tue, 02 Sep 2008 14:19:10 GMT

My chevy express has a side mounted wheelchair lift and I would like to the manufactuers mpg rating for city/highway on thos vehicle.

Front end issue on a Chevy Express - tires involved?

zoltan64030 — Thu, 25 Sep 2008 10:05:30 GMT

We own a '98 Chevy Express 12 passenger, with about 120,000 miles on it. Bought new tires about a year ago and have been having front end trouble ever since - vibration at highway speed, a feeling of almost 'bouncing' as brakes are applied. I've taken the van to 3 places to get an idea of what's wrong -

- dealership (not where I purchased the van) said I needed new pitman arms and idler arms and new shocks

- tire retailer (who sold me the tires) said I needed new pitman arms and idler arms...but said the shocks were fine

- independent shop said the pitman arms and idler arms were fine, the shocks were bad...and that the tires were a) out of round and b) were the wrong tires for the vehicle and the type of driving we do

Not being a car guy...I'm confused, and being a self-employed missionary, I want/need to make sure I'm making the right decision. Any help woudl be appreciated!

Trying to appraise a 2008 Chevy Express but the Express does not show up on your list of used 2008 Chevys?

jacassar — Wed, 15 Oct 2008 00:44:44 GMT

Am I missing something? Other 2008 models are available to choose from but not the Express van. I am trying to appraise a 2008 Express LT 3500 15 passenger van with 16,000 miles. Thanks!

Radiator cracked on a 2000 Chevy 1500 Express van.

orchiddj — Tue, 04 Nov 2008 06:23:36 GMT

2000 Chevy 1500 express van 4.3. 116K.

One of the plastic tanks on radiator has a crack.

Can a radiator shop replace the tank or should I buy a new radiator?

I checked local parts stores and am looking at $ 200 - $ 300. Looked online and can get for about $ 150 delivered. Is there any difference other than the price?

Thanks
Jim

08 Chevy Express 2500, Need part # of factory am fm cd radio to replace original am fm.

mjm0073 — Mon, 19 Jan 2009 23:53:54 GMT

looking to replace original radio with a oem am/fm/cd player with aux input one that will plug right in and mount the same way . i need a gm part number please. thank you

2002/3 Chevy Express 2500 is overheating. There's antifreeze present. Seems to be temperamental.

cttileguy — Fri, 23 Jan 2009 13:13:47 GMT

one instance i released the radiator cap and no signs of overheating there,a little pressure was noted then the temp went down and i continued home ok.today it overheated and wouldn't go down.i want to know any info before i take it in to get repaired by a garage.

is anyone having the same problem as me with my 2008 Chevy Express Cargo? When fueling, the pump will not stay on.

arieizhak — Sat, 31 Jan 2009 15:10:53 GMT

I have 2008 cargo 3500 Express and every time i fuel and let the nozzle seat in the natural position (dowen) the pump will click off like the tank is full, unless I hold the nozzle up in one position I will not be able to fuel.

How many fuel injectors are in a Chevy 1500 Express van?

superbebo — Tue, 10 Feb 2009 17:18:43 GMT

want to compare prices

Why is antifreeze leaking on top of my engine? 2000 Chevy Express.

ChevyEx1959 — Mon, 16 Feb 2009 13:08:28 GMT

I have a 2000 Chevy Express. I can't figure out where the leak is coming from.

I have a 98 Chevy Express van. Starter is fine but engine will not start every so often. Battery and connecter good.

tpm71 — Sat, 16 May 2009 09:41:13 GMT

I just had a starter put in and within 30 minutess it happened again. When I turn the key it just keeps clicking until I hit the brakes. If I let it sit for awhile it will start again. Otherwise I have to jump the battery. But the battery is new and so are the wires. Volts go down to nearly nothing.

My wife said before it happened one time, that the inside lights flickered a bit. I brought it to a guy who specializes in electric work but he couldn't find anything. Anyone have any ideas I would love to hear them. This is getting very tiring already. Thanks in advance.

2004 Chevy 3500 express with 23' RV by Four Winds. Coolant temp max range climbing steep grade gauge rises from 100 to 260 degrees.

billboard — Thu, 18 Jun 2009 09:46:06 GMT

When climbing 2000' in 2.5 miles coolant temp. rises to 235 degrees.

After climb gauge returns to 208 degrees is this normal. Could the automatic clutch fan be the problem? I have changed coolant and thermostat.

2000 Chevy 2500 cargo van won't start.

cac1966 — Thu, 20 Aug 2009 16:30:44 GMT

Friend has Cargo van 2000 model with over 200,000 miles on it. It is a 2500 model and has v-6 with automatic trans. It wont start, he has fuel to the injectors but that is far as it goes. The fuel pressure is good, he used starting fluid and van starts for a couple of seconds. Is this a sensor possibly and if so which one is it. He doesn't have the money to take it to a dealer and is retired.

Thanks for you help in advance.

Braking system of a 1998 Chevy 1500 Express van/

wamp — Mon, 19 Oct 2009 02:49:15 GMT

When I put the brakes on quickly the van pulls to the left at first.

Is this caused by the equalizer to the front brakes?

What is the length of the cargo space in a 2005 Chevy Express 1500 Cargo Van?

magiking — Tue, 20 Oct 2009 23:27:27 GMT

Details are in question!

Chevy Express rear passenger seat belts. Are there aftermarket replacements? Can't afford dealer charge.

vanmom66 — Wed, 18 Nov 2009 17:47:13 GMT

I have a 08 Chevy Express 12 passenger van and the rear 3 point retractable seat belts have become frayed in places. The dealer is going to charge me a ton of money I don't have. Any ideas? Aftermarket or other ideas?

He says the warranty will not kick in because he thinks maybe my dog did it. And I just do not know for sure that he didn't.

1998 Chevy 1500 Express Van. I changed plugs at 106,000...do I need to change rotor, distributor cap and wires too?

shelsta — Sun, 06 Apr 2008 20:41:04 GMT

no issues and everything runs fine...just wondering if I should also change rotor, dist. cap, and wires too for insurance in the long haul. Now at 106,000 miles...

Does the 6.0L engine in the 2008 Chevy Express van include cylinder deactivation?

pmanolakis — Sat, 09 Aug 2008 19:35:06 GMT

2008 Chevrolet express van

What is better for driving in the snow, RWD or AWD? Looking to buy a Chevy Express.

bearwoman — Wed, 19 Nov 2008 21:32:39 GMT

I'm thinking of buying a Chevy Epress passenger van.

The air bag light on my 2004 Chevy 3500 Express van comes on and blinks then goes out then comes back on and stays.

bankshotbob — Mon, 19 Jan 2009 22:20:35 GMT

what could be the problem

Sensor related? Chevy Express 1500.

slilly6 — Fri, 06 Feb 2009 10:07:04 GMT

Here is the background on my problem.

Vehicle: 2002 Chevy Express 1500 93000 miles

Until last Friday Jan 30th van was running perfect.

I had been driving for about 30 minutes, disembarked from the freeway and driving city streets when power of acceleration stopped. As I went to push down the accelerator, nothing happened. It was as a brick was under the pedal.

I slowed to a stop - vehicle still idling but couldn't get it to go. Smelled a metal smell - turned off vehicle. One minute later I was able to push down on the accelerator so I turned on the van and quickly drove home (abt 1/4 of a mile). Van ran really rough at first and engine light came on. Repeated behavior when I got to my driveway. Again turned it off and then restarted to get into my garage.

Next day - behavior was duplicated.

Day 3 - had the vehicle towed to a shop. They cleared the codes (PO300 & PO1381) and could not locate the problem. They drove the vehicle abt 10 miles three different times and the problem would not duplicate.

Picked up vehicle - drove 10 minutes when accelerator pedal "grabbed" and became sticky. It would be hard to depress but not impossible. Engine light would come on, engine would run rough and pedal hard to depress. Light would go off, engine would run smoother and pedal was smooth. This continued for about 20 minutes. Then engine light came on and stayed on but although running slightly rough - pedal no longer sticks.

Now engine light remains OFF, engine a bit rough and pedal is fine.

Any thoughts?

TIA

When the headlights are on, my brake lights don't work. Headlights off, brake lights work fine. 1998 Chevy 1500 Express.

grandpa48 — Thu, 26 Feb 2009 23:14:56 GMT

When I have the headlights off the brake lights work fine work fine. The tail lights and turn signals work fine

Will a 97 Chevy Express van grill assembly fit a 97 Savana van?

toons2 — Sat, 04 Apr 2009 16:11:20 GMT

Will a 1997 chevy express grill assy. fit a 1997 gmc savana van?

TMV of a new 2008 Chevrolet G2500 Express Cargo Van with less than a 1,000 miles? New on car lot in Washington State.

rlsx2 — Sun, 19 Apr 2009 13:19:35 GMT

What is the range of values & true market value of a new van listed above. Wenatchee, Washington

Where can I find a free owner's manual for a 2003 Chevy Express?

ridnawave — Sat, 23 May 2009 20:09:20 GMT

I just bought a 2003 Express without a manual. Where can I download a free owners manual?

Where do I find body kits for Chevy Express Cargo Vans?

crossroadsatt — Sun, 28 Jun 2009 23:14:48 GMT

I want to use a Chevy Express for my business. To make it stand out, I would like to midify the body somewhat by adding larger fenders, ground skirting, etc. I can find kits for Econolines, but can't find anything for a Chevy Express.

03 Chevy Express Cargo van stalls when coming to stops. Not fuel pump, filter, alternator, battery, or belt.

jando — Mon, 10 Aug 2009 22:02:15 GMT

Van stalls at low idle fine at higher rpms checked or replaced att batt fuel pump and filter. 2003 Chevy Cargo Express 2500 6.0l. No check engine light. The only thing that happens is amps drop below 14 and van stalls.

2000 Chevy Express will not start.

mark8299 — Tue, 18 Aug 2009 12:34:43 GMT

I have a 2000 Chevy Express 1500 5.7l 159000 mi. The van will only crank but not start. Changed the fuel filter 2 months ago. I remove the fuel line on outlet on the fuel filter and fuel will shoot out when the key is on or when cranking. The only way can get it started is to give it a shot of starting fluid or carb cleaner. Also when it is running and I give it gas it will not downshift it just accelerates. Could it be the fuel pump going bad or something else. Need help.

2000 Chevy Express will not start.

mark8299 — Tue, 25 Aug 2009 11:11:15 GMT

2000 Chevy Express will not start.

I have a 2000 Chevy Express 1500 5.7l 159000 mi. The van will only crank but not start. Changed the fuel filter 2 months ago. I remove the fuel line on outlet on the fuel filter and fuel will shoot out when the key is on or when cranking. The only way can get it started is to give it a shot of starting fluid or carb cleaner. Also when it is running and I give it gas it will not downshift it just accelerates. Could it be the fuel pump going bad or something else. Need help.

07 Chevy Express. ABS and Stabilitrak lights flashing and beeping. Brakes chattering sometimes.

jstp09 — Thu, 19 Nov 2009 23:06:21 GMT

ABS and Stabilitrack lights start flashing together with a loud beep. After driving a few minutes, both stay on steady. On some occasions when you brake suddenly, the brakes chatter. Am getting a code for the right rear wheel ABS sensor. I took out both sensors and switched them. I reset codes and as soon as you press the brake the light comes on again and I get the code for the same wheel, even though the sensors were switched.

2000 Chevy 3500 Express engine skip, loss of power. Changed a lot of parts. No results.

jrstuffytruck — Tue, 07 Apr 2009 09:10:52 GMT

Ok this is what was replaced:

cap, rotor, button, plugs, fuel filter, complete fuel injection, map sensor, complete air intake gaskets-upper and lower, fuel pump runs at 60lbs, thermostat, cannot figure out why runs like crap, good compression, 95,000 miles not beat on, new air filter.

Now I give anyone have similar problem or know what I missed. Thanks